Back to Top Skip to main content

The art of moulage

Combat Medic Training program students at the Medical Education and Training Campus at Joint Base San Antonio-Fort Sam Houston conduct an emergency cricothyrotomy on a “casualty” during simulation training. The “wounded” manikin also presents with facial burns that were created with moulage techniques. (DoD photo by Lisa Braun) Combat Medic Training program students at the Medical Education and Training Campus at Joint Base San Antonio-Fort Sam Houston conduct an emergency cricothyrotomy on a “casualty” during simulation training. The “wounded” manikin also presents with facial burns that were created with moulage techniques. (DoD photo by Lisa Braun)

Recommended Content:

Health Readiness

JOINT BASE SAN ANTONIO-FORT SAM HOUSTON, Texas — The saying “train like we fight” is a common idiom in the military training spectrum. As combatants, service members must train for a variety of scenarios that will prepare them to succeed when engaged in real-life conflicts.

Simulation plays an important role in preparing enlisted medical trainees at the Medical Education and Training Campus, or METC, at Joint Base San Antonio-Fort Sam Houston to respond appropriately when faced with an actual life-or-death situation.

For the combat medic trainees in the Department of Combat Medic Training, or DCMT, program who, due to the sheer size and number of classes, will not have an opportunity to see real patients until after they graduate from the program, the realism goes a step further.

The use of high-fidelity human patient simulators that mimic actual patient encounters will prepare Soldier medics with the basic skills that will save lives – on and off the battlefield.

When the training scenario calls for treating casualties with combat wounds or injuries, however, less expensive generic manikins are incorporated and given a makeover to look the part because not many manikins have wounds already on them.

“To better simulate battlefield wounds or injuries our simulation instructors have become moulage artists to make realistic wounds and injuries that give these manikins more realism,” said Donald Parsons, DCMT program director. “This allows the students to actually see and treat wounds they will see on the battlefield, but they can also make their mistakes on the manikin without risking someone’s life.”

These realistic injuries may include an amputation, head and chest gunshot wounds, and other traumas associated with combat injuries. As the combat medic trainees, or Soldier medics as they are called in the training environment, respond to the simulated casualty they are simultaneously reinforcing the skills they learned in the classroom – from a basic injury assessment to more complex wound care.

Camille Espinoza, a civilian DCMT training instructor and simulations technician, heads the process of transforming a generic, low-fidelity manikin into a combat casualty. As an art, moulage is a process of trial and error so Espinoza is always learning new techniques. Her team offers ideas and assists with some of the moulage application.

Espinoza has had to create a way for students to apply needle chest decompressions, or NCD, on the manikins, for example. An NCD is a medical procedure that is most commonly used to treat patients suffering from a punctured or collapsed lung by inserting a needle with a catheter on the end through the chest cavity.

In the past, students would utilize a task trainer for working on specific procedures, such as a NCD, tourniquet, or wound packing among others. The students would assess the manikin first then turn to a task trainer to treat the wounds.

Espinoza modified the chests on the low-fidelity manikins, which are made out of PVC, so that the NCD insertion spots are soft enough to allow students to puncture through the manikin without causing the catheter to bend.  She also gave them trachea inserts that she carved into the manikins, and added injuries that look more realistic.

Now, students can examine and assess the “casualty,” inspect the location of the wounds and perform all of their interventions directly on the manikin itself. A set of manikins was created to use just for testing as well.

One of the biggest challenges with creating the wounds is that the manikins take a lot of abuse when students practice with them because they get moved around a lot to different outdoor locations where dirt and other elements wear down the moulage effect.

Many of the materials would break down or wear off too quickly, so experimenting with different moulage techniques and materials that make the wounds last longer is part of the process. Feedback from instructors was also an important factor in determining what works and what doesn’t.

“A lot of the stuff that special effects people do is usually a one or two time use, so it doesn’t need to last a long time,” Espinoza explained. “Unfortunately, I have students from three Whiskey teams that come down to the simulation lab so we’re running around 1,000 Soldiers through there. I had to figure out what the best materials were, the least expensive, the most effective; there was a whole lot of stuff that was going on trying to come up with the best way to apply the moulage and then hope it doesn’t break up too quickly. It’s all trial and error.”

Through the process of trial and error, Espinoza discovered that silicone-based material helps the moulage stay on longer. If it gets worn out it can easily be cleaned up and redone. The manikins can potentially be used hundreds of times before the moulage wears down, depending on the type of injury.

Some wounds, like amputations, don’t last as long because the manikins are being dragged continuously through the dirt during training. Facial wounds, though, tend to last longer because the face does not make contact with hard surfaces.

Modifying a manikin may take two or three days, depending on the wound being depicted. Some injuries needs to be created in steps and can be time consuming, so an assembly line process is ideal.

Espinoza and her team can line up three to five manikins, start working on one then move on to the next one while the previous one is drying, solidifying or cooling from having to heat the plastic to soften it for an effect.

The most important factor is making sure that the manikin is dry before moving on to the next step. Rushing through a modification may result in the moulage not staying on.

Depicting a shrapnel wound, for example, means that Espinoza will need to cut into the manikin. In order to do this, the area on the manikin where the wound will be created is heated in order to soften it so it can be cut and manipulated to form a wound. Then it will be painted to look realistic and set to dry.

If it’s possible to make use of materials already on hand, Espinoza will find a way to incorporate them into her design as well.

“We don’t want to use more than what we need or waste more than what we have,” she said.

Espinoza has used the popcorn material used for packing boxes to stuff the lower portion of manikin legs where a wound is depicted before adding foam to the area so students could learn how to pack the wound and practice applying tourniquets.  Prior to that, the foam would crack and fall apart.

“We just had to modify a lot of the stuff that we did in order to find the best way to do it.” 

Espinoza takes great pains to ensure she creates as realistic a product as possible.

“I want the students to get that shock and awe when they see the injuries without having that reaction the first time seeing it on a person, on a Soldier, on their battle buddy,” she added. “I would rather they have something as realistic as possible in these manikins without having somebody actually injured." 

A fellow instructor of Espinoza’s, who is now retired, once told her that what they’re doing now is saving lives through other people's hands. Those words have always stuck with her.

“I can do my job through these medics. If I can make something as real as possible so they can get that, ‘oh my god, this is for real!’ reaction and it makes sense, that’s all I really care about. I can get in their head and make them understand that what they’re doing makes a difference.”

To Espinoza, making mistakes on the manikins is the point of the training.

“You have to make mistakes to learn. If the students do it wrong here they can learn from it. I want them to do it wrong, because if they always do it right then what are they going to learn?"

“That’s exactly what I’ve done with these manikins,” she added. “I’ve had to make mistakes to learn how to make them better for the students to make their mistakes so they can get better. I’d much rather they do that here then on the battlefield.”

Disclaimer: Re-published content may be edited for length and clarity. Read original post.

You also may be interested in...

Mid-season flu activity increase: How to keep healthy

Article
1/22/2020
Navy Hospital Corpsman Kenny Liu, from San Jose, assigned to USS Gerald R. Ford's medical department, prepares a needle with a flu vaccination in the ship's hangar bay. (U.S. Navy photo by Mass Communication Specialist Seaman Apprentice Angel Thuy Jaskuloski)

Despite reports of increased flu activity in the U.S., the Military Health System remains vigilant

Recommended Content:

Immunization Healthcare | Influenza Summary and Reports | Health Readiness | Influenza Seasonal | Vaccine Recommendations | Vaccine-Preventable Diseases | Armed Forces Health Surveillance Branch

HPV vaccine now recommended for those up to age 45

Article
1/14/2020
https://www.nfid.org/infectious-diseases/hpv/ Recent CDC and FDA guidance recommends that men and women up to 45 years of age get vaccinated to protect against the Human papillomavirus (HPV). HPV is the most common sexually transmitted infection and can cause certain cancers and genital warts. More than 14 million new HPV infections occur in the U.S. each year, and about 80 percent of sexually active men and women are infected with HPV at some point in their lives. (National Foundation for Infectious Diseases image)

HPV shot protects against a host of diseases in men, women

Recommended Content:

Conditions and Treatments | Health Readiness | Preventive Health | Men's Health | Women's Health | Immunization Healthcare | Vaccine-Preventable Diseases | Vaccine Recommendations

U.S. Transportation Command: DoD’s manager for global patient movement

Article
1/9/2020
An ambulance bus backs up to the Mississippi Air National Guard C-17 Globemaster III as Airmen prepare to unload patients at Joint Base Andrews, Maryland. The bus transports the ill and/or injured to Walter Reed National Military Medical Center in Bethesda, Maryland. JBA and Travis Air Force Base, California, serve as the primary military entry points or hubs for patient distribution within the continental United States. (U.S. Air Force photo by Karina Luis)

On a weekly basis, USTRANSCOM moves up to 40 patients from overseas to CONUS

Recommended Content:

Health Readiness | Military Hospitals and Clinics

Joint Chiefs say mind, body, spirit all part of Total Force Fitness

Article
1/7/2020
Image of a Marine climbing a rope ladder

2020 focus on factors making service members, families “resilient”

Recommended Content:

Health Readiness | Operation Live Well

Navy Medicine demonstrates Virtual Health options to Africa

Article
1/6/2020
Air Force Staff Sgt. Danny Lim practices conducting a throat examination on Army Sgt. Harvey Drayton at Chabelley Airfield, Djibouti. Drayton and Lim were introduced to the Telehealth In A Bag system during a recent visit that included personnel from Regional Health Command Europe's virtual health team. (U.S. Army photo by Russell Toof)

Djibouti hosts the largest U.S. American military base on the African continent

Recommended Content:

Health Readiness | Military Hospitals and Clinics

MSMR Vol. 27 No. 1 - January 2020

Report
1/1/2020

A monthly publication of the Armed Forces Health Surveillance Branch. This issue of the peer-reviewed journal contains the following articles: Carbon Monoxide Poisoning, Active and Reserve Component Service Members and Non-Service Member Beneficiaries of the Military Health System, U.S. Armed Forces, July 2009–June 2019; Respiratory Pathogen Surveillance Trends and Influenza Vaccine Effectiveness Estimates for the 2018–2019 Season Among Department of Defense Beneficiaries; Brief Report: The Early Impact of the MHS GENESIS Electronic Health Record System on the Capture of Healthcare Data for the Defense Medical Surveillance System; and Brief Report: Incidence and Prevalence of Idiopathic Corneal Ectasias, Active Component, 2001–2018.

Recommended Content:

Health Readiness | Public Health

Air Force studies fatigue, sleep to enhance readiness

Article
12/31/2019
An Air Force Airman sleeps inside a C-17 Globemaster III during a flight over an undisclosed location in support of Operation Freedom Sentinel. (U.S. Air Force photo illustration)

Good sleep habits are closely related to overall health and performance

Recommended Content:

Health Readiness | Sleep

Guard and Reserve crucial to CCATT expansion

Article
12/20/2019
Air Force Maj. Lori Wyatt, a Critical Care Air Transport Team nurse, assigned to the 167th Airlift Wing, Martinsburg, West Virginia, assembles a gurney during a casualty evacuation training at the Raleigh County Memorial Airport. The Air Force is increasing the number of CCATTs to support future readiness requirements. (U.S. Air Force photo by Master Sgt. De-Juan Haley)

The Guard and Reserve support the bulk of aeromedical evacuation, CCATT capabilities

Recommended Content:

Health Readiness

Air Force, Army medics save groom

Article
12/19/2019
Airmen from the 18th Aeromedical Evacuation Squadron simulate life-saving procedures to a training manikin onboard a KC-135 Stratotanker during an exercise out of Kadena Air Base, Japan. The 18th AES maintains a forward operating presence, and was instrumental in saving an Airman’s life. (U.S. Air Force photo by Senior Airman Matthew Seefeldt)

NCO’s first aeromedical evacuation mission was definitely challenging

Recommended Content:

Health Readiness | Military Hospitals and Clinics

McCaffery AMSUS Remarks 2019

Publication
12/5/2019

McCaffery statements made during the 2019 annual meeting of AMSUS

Recommended Content:

Health Readiness

McCaffery calls for military medical strategic framework for warfighting readiness

Article
12/5/2019
Assistant Secretary of Defense for Health Affairs Tom McCaffery speaks on Thursday at the annual meeting of AMSUS, the Society of Federal Health Professionals. McCaffery announced to the nearly 2,000 conference attendees that he has asked the Military Health System's senior leadership to develop and codify a formal strategic framework to guide integrating and optimizing all MHS components to meet his vision. (MHS photo)

'New reality' includes tight synchronization, expanding partnerships

Recommended Content:

Health Readiness | MHS Transformation

MSMR Vol. 26 No. 12 - December 2019

Report
12/1/2019

A monthly publication of the Armed Forces Health Surveillance Branch. This issue of the peer-reviewed journal contains the following articles: Editorial: Mitigating the risk of disease from tick-borne encephalitis in U.S. military populations; Tick-borne encephalitis surveillance in U.S. military service members and beneficiaries, 2006–2018; Case report: Tick-borne encephalitis virus infection in beneficiaries of the U.S. military healthcare system in southern Germany; Update: Cold weather injuries, active and reserve components, U.S. Armed Forces, July 2014–June 2019

Recommended Content:

Health Readiness | Public Health

Military medical reform is an opportunity to make trauma care better

Article
11/21/2019
Army Lt. Gen. R. Scott Dingle, U.S. Army Surgeon General, spoke to surgeons at the Defense Committee on Trauma and Committees on Surgical and En Route Combat Casualty Care Conference held in San Antonio, Texas, on November 13. He spoke about the plans for current and future trauma and surgical initiatives within Army Medicine and that surgeons must be involved in improving trauma care during this time of military medical reform. (U.S. Army Image by Rebecca Westfall)

There is an opportunity to bring real change to how the military handles combat trauma care

Recommended Content:

Health Readiness

Preventing seasonal influenza

Article
11/13/2019
Air Force Staff Sgt. Jaqueline Mbugua and members of the Massachusetts Air National Guard’s 102nd Medical Group traveled to the Roxy Theater on Joint Base Cape Cod to provide flu shots to Airmen Nov. 2, 2019. (U.S. Air Force photo by Tech. Sgt. Thomas Swanson).

The best way to prevent the flu is to get vaccinated every year

Recommended Content:

Health Readiness | Immunization Healthcare | Immunizations

MSMR Vol. 26 No. 11 - November 2019

Report
11/1/2019

A monthly publication of the Armed Forces Health Surveillance Branch. This issue of the peer-reviewed journal contains the following articles: Editorial: Mitigating the risk of disease from tick-borne encephalitis in U.S. military populations; Tick-borne encephalitis surveillance in U.S. military service members and beneficiaries, 2006–2018; Case report: Tick-borne encephalitis virus infection in beneficiaries of the U.S. military healthcare system in southern Germany; Update: Cold weather injuries, active and reserve components, U.S. Armed Forces, July 2014–June 2019

Recommended Content:

Health Readiness | Public Health
<< < 1 2 3 4 5  ... > >> 
Showing results 1 - 15 Page 1 of 40

DHA Address: 7700 Arlington Boulevard | Suite 5101 | Falls Church, VA | 22042-5101

Some documents are presented in Portable Document Format (PDF). A PDF reader is required for viewing. Download a PDF Reader or learn more about PDFs.